 |
|
|
[Subscribe to Daily Digest] |
 | [Main Performance Bulletin Board | BBFAQ |
Prev by Date | Next by Date | Post Followup ]
Member Login / Signup - Members see fewer ads. - Latest Member Gallery Photos
Re: Stage 5 misfiring issues Posted by Chadwick [Email]  (#569) [Profile/Gallery]
(more from Chadwick) on Thu, 22 Nov 2007 08:50:09
In Reply to: Re: Stage 5 misfiring issues, skinters, Thu, 22 Nov 2007 01:44:11 Members do not see ads below this line. - Help Keep This Site Online - Signup |
Hey there,
I've had 3 or 4 DI's on the car in the past few months just tossing them around. Here's a list of everything that's been done to the car, everything you've mentioned has been changed.
Apr 06 -
1. Replace alternator
2. change oil
3. added sony x-plod 4 way rear component speakers, infinity speakers in font
May 06 -
1. Replace tail pipe
2. Replace fog light bulbs
3. Replace PCV valve
4. Change spark plugs, NGKBP7’s
June 06 –
1. Replace fog light switches
2. Clean sunroof drains
3. Clean aquarium drains
4. Flush coolant
5. Cleaned leather
July 06 –
1. Airbox mod completed
2. Replace ACC unit
3. Added boost gauge
4. Replace headlight relay
5. Refinished headliner, A pillar covers
6. Oxygen sensor replaced, Bosch 3 wire
October 06 -
1. Change oil
2. Change small coolant overflow hose (radiator to reservoir)
3. Changed all vacuum hoses
4. New exhaust hangers
January 07 –
1. Replaced serpentine belt
2. Replaced idler pulley
3. Replaced Tensioner pulley
4. Replaced Front brake rotors
5. Replaced reverse threaded tensioner bolt and tensioner bracket
6. Cleaned leather
7. Added Greddy style blow off valve
8. Custom intake pipe fabricated (IC to Turbo)
9. Replaced headlight switch
March 07 –
1. Changed transmission fluid (10w40 Dyno)
2. Changed oil
3. Adjust AC clutch gap (still intermittently cuts out, compressor will be replaced)
4. Added center gauge holder
5. New front wipers, Bosch Icon
April 07 –
1. Front windshield and seal replaced with OEM, no rust found
2. Used McGuire’s clay bar on exterior, then waxed and sealed
May 07 –
1. Change head gasket
2. Added JT 3 Inch downpipe
3. Heater core hoses (inlet and outlet)
4. R&R turbocharger
a. New td04-15T purchased from Justin Duthie, new seal rings
5. Replaced crankcase vent hose
6. Replaced turbo water send to PCV hose
7. Flush coolant
8. Change spark plugs, NGKBP7’s
9. Change oil
a. Fully converted to Synthetic motor oil, Mobil 1 10w30 used
10. State inspection
11. ABS light cleared
June 07 –
1. Encountered pass side rear shock tower rust
a. Ground out, por 15’d. Made metal brackets and welded in
2. Replaced blown rear speakers with new Sony Xplod
3. Flushed brake fluid (clutch)
July 07 –
1. Added rocky black arm rest (purchased from Justin Duthie)
2. R&R Drivers side seat cover with like new used
3. Added 2x12 subwoofers and amplifier + wiring (Rockford Fostgate subs & wiring, alpine amp)
4. R&R Blow off valve connection boot
5. R&R rear brake pads and rotors (bled rear calipers)
6. Worked on pass rear seat recline issue, completed sheath repair, seat still does not recline properly. Sheath will need replaced
7. R&R right side rear caliper (lifetime warranty, advance)
8. R&R fan switch on radiator
9. R&R Coolant temp sensor on intake manifold
10. Wired in Autometer air/fuel ratio gauge
August 07-
1. Replaced blow off valve clamps with constant torque hose clamps
2. Added clear side blinkers
3. Had Jak Stoll reprogram the ECU to stage 4 at SOC 07.
September 07 – 223k miles
1. Installed Bilstein HD full suspension kit, front and rear
2. Installed polyurethane rear sway bar bushings
3. Installed polyurethane front drop link bushings
4. R&R Headlight switch
5. Replaced screw in handbrake cover
6. R&R license plate bracket
7. R&R Rear décor panel
8. Purchased Valentine1 radar detector
9. Replaced drivers side front lower bumper cover
10. Replaced crank pulley inspection cover on serpentine belt cover
11. Replaced coin tray/cigarette lighter unit in dash
12. Replaced rear shock bolts
13. Replaced rear sway bar bushings (on shock mounting bolts)
14. Registered vanity plate “THE STIG”
15. Added Valentine 1 radar detector hardwire kit
16. Pirelli P4 tires (2) on mounted and put on front of car, P3000’s switched to the rear
17. Lexol treated and armoalled interior
18. 9/18/07. 227k miles. Had front end aligned at Meineke Car Care Center. Morgantown, WV.
October 07 – 225k miles
1. Installed front mount intercooler kit
2. Installed 2.5” piping from turbo to throttle body with stainless T clamps and blue silicone boots
3. Replaced lower radiator hose
4. Replaced reservoir to water pump hose
5. Repaired front bumper lower lip spoiler crack
6. Replaced water pump and o rings
7. Changed spark plugs
8. Added Jak Stoll Stage 5 ECU
9. Installed Volvo “Green Giant” Injectors
10. Replaced coolant reservoir cap
11. Replaced headlights with better condition used
12. Added 2.5” blow off valve flange pipe
November 2007 – 226k Miles
1. Replaced fuel pump with Walbro 225 higher output pump
2. Replaced fuel pump send check valve
3. Replaced fuel pump return check valve
4. Replaced hose from throttle body to crankcase vent hose
5. Replaced hatch shocks (2)
6. Changed oil, 227k miles
posted by 75.108.94...
, Wed, 21 Nov 2007 21:53:48, Mon, 26 Nov 2007 15:11:56, Thu, 22 Nov 2007 11:40:18, Thu, 22 Nov 2007 08:50:09 <-- Viewing This Message, Thu, 22 Nov 2007 14:08:10, Fri, 23 Nov 2007 07:05:55, Thu, 22 Nov 2007 16:16:09
, Thu, 22 Nov 2007 19:05:47
No Site Registration is Required to Post - Site Membership is optional (Member Features List), but helps to keep the site online
for all Saabers. If the site helps you, please consider helping the site by becoming a member.
 |
 |
 |
 |
 |
